Guldmann GLS5.2 User manual

8
6
4
18
3
13
15
16
17
14
21
912
10
11
7
3
3
5
Operators check list before use
• Make sure the lifter is moving freely on its castors.
• Operate the brakes (10) to make sure they are
working.
• Lift & lower the lifting boom (2) via the control
buttons (16) on the hand control (8).
• Check that the base adjustment (17) is opening
and closing, via the hand control (8).
• Check the emergency function up/down by
pressing the buttons (17) on the control box (3).
Check the manual function by turning the knob
(7) in the direction of the arrow.
• Check that the emergency stop button (6) is
working. To release the emergency stop, take off
battery by pushing buttons on battery sides, and
pull battery out and push in place again.
• Release Knee pad adjustment knobs x 2 (12)
the pad should move up / down and slide in / out,
tighten to lock.
• Make sure footplate (11) is secure and clean.
Charging options
• Charger integrated in control box - plug net
cable into power socket.
• When the power is plugged in, the green LED
light on the control box lights up.
• The green and yellow diode on the control
box (3) illuminates during charging, when fully
charged the yellow diode turns off.
Quick Guide - GLS5.2 Active Lifter
1. Sling attachment hooks
2. Lifting boom
3. Control box
4. Battery
5. Push handle
6. Emergency stop
7. Emergency lowering
manual
8. Hand control
9. Actuator
10. Rear braked castor
11. Foot plate
12. Knee pad & adjustment
knobs x 2
13. Battery indicator
14. Service indicator
14. Overload indicator
16. Lifting boom up/down
17. Base adjustment
18. Emergency function
up/down, battery-,
service- and overload
indicator

V. Guldmann A/S
Graham Bells Vej 21-23A, DK-8200 Aarhus N
Tel. [phone]
[email protected]
www.guldmann.com
Scan here for user manual, etc.
concerning use of the GLS5.2.
Accessories
Sling attachment hooks
You have the option to use either the outer hooks or
inner hooks. (A risk assessment MUST be carried out
before attempting a lift).
Place the sling strap in the hooks. Upon lifting make
sure that the strap maintains its position.
Lifting sling
We only recommend using the designed slings for the
“Active Lifter.” The sling must be checked before every lift
– (please see sling user manual for guidance). Label must
be intact and readable.
Daily cleaning and
maintenance
Clean with a damp cloth and ordinary detergent. Do
not use strong acids, bases or alcohol when cleaning.
See user manual.
© Guldmann GB-09/2022
Indicator lamps and audio warning
Status Indicator lamps Audio signals Possible GLS5.2 signals
Up Down Leg spread Emergency
down
Hand control
Battery charged 75-100% 3 Green lights x x x x
Battery charged 50-75% 2 Green lights x x x x
Battery charged <50% 1 Green light x x x x
Critical low battery,
two cycles left
1 Yellow light Beeps at button activation x x x x
Lifter service Yellow. Is lit during
use and 2 minutes
after
x x x x
Overload Yellow. Flashes 3
times + lights up
for 10 seconds
x x
Control box
Charger Green + yellow
Charged Green