kingsley-bate CR - 25 User manual

KINGSLEY –BATE
Fine Garden Furniture
ASSEMBLY INSTRUCTIONS FOR THE CR - 25
RIGHT END FRAME BACK LEFT END FRAME
* NOTE:
A TENON
B MORTISE HOLE
SEAT
STEP-I
Unpack, inspect and lay the parts on a clean, flat, soft surface to avoid marring the wood.
NOTE: During assembly of the furniture please match all the joints with the
corresponding letters or numbers stamped on the furniture.
STEP-II
Place the LEFT END FRAME on its side with the mortise joints
facing up. Insert the BACK and BOTH SEAT RAILS into the LEFT
END FRAME as shown in the diagram. If necessary, gently rock
the component pieces while pushing down until all joints fit snugly
together. It is important to match the numbers on the tenons
with those on the mortise holes.
STEP-III
Rest the SEAT between the FRONT and BACK
SEAT RAILS on the LEFT END FRAME. Fit
the RIGHT END FRAME onto the tenons of the
BACK and the two SEAT RAILS. If necessary,
you may wish to gently hammer the RIGHT
END FRAME with a rubber mallet to insure that
all the joints fit snugly together.

STEP-IV
Secure the LEFT and RIGHT END FRAMES to
the FRONT and BACK SEAT RAILS with the
knock-down bolts provided. Tighten the bolts
with a proper screw driver.
STEP-V
Using a hammer, drive the dowels into position
as shown in the diagram. Hammer dowels into
respective joints, making sure not to hit other
parts of the chair. To avoid dimpling the wood,
we suggest that you place a block of wood
between the dowel and the hammer head for the
last few blows. DO NOT FORCE DOWELS.
If the dowels are not completely flush, you can use a saw to cut the ends and then the
sanding block to smooth the tops.
STEP-VI
Insert the brass screws into their respective pre-drilled holes on the
underside of the SEAT (see assembly diagram).Please use a proper
screw driver.
IF YOU HAVE ANY QUESTIONS REGARDING THE ASSEMBLY OF YOUR
KINGSLEY-BATE FURNITURE, PLEASE CONTACT THE KINGSLEY-BATE
DEALER NEAREST TO YOU OR KINGSLEY-BATE DIRECTLY. WE THANK YOU
FOR CHOOSING OUR FURNITURE.
* KINGSLEY-BATE WILL NOT TAKE RESPONSIBILITY FOR DAMAGE
IF THESE INSTRUCTIONS ARE NOT FOLLOWED PROPERLY
7200 Gateway Court, Manassas, Virginia 20109
Phone [phone], Fax. [phone]