kingsley-bate NT-70 User manual

KINGSLEY~BATE
Fine Garden Furniture
ASSEMBLY INSTRUCTIONS FOR THE NT-70
CHAISE FRAME BACK LEG FRONT LEG HARDWARE
STEP-I
Unpack, inspect and lay the parts on a clean, flat, soft surface to avoid marring the wood. Lay
CHAISE FRAME on its back side with mortise holes facing up as shown on the assembly
diagram.
STEP-II
Before inserting the brass bolts through the back leg, slide
one washer onto each bolt. Insert the bolts through the back
leg and slide on the second washers. Then slide wheel onto
the bolt and connect the wheel assembly with the short axle.
Screw in by hand and tighten with a standard adjustable wrench. Do not tighten too hard or the
wheels will not turn. Complete the WHEEL ASSEMBLY as shown in the above photographs.
STEP-III
Before inserting the brass bolts to the front legs, slide one washer onto each bolt. Insert the
bolts through the front legs and then connect with long axle. Screw in by hand also tighten with
the standard adjustable wrench.

STEP-IV
With a rubber mallet gently knock
the front and back leg assemblies
into their corresponding place. Be
sure to match the numbered
tenons with the corresponding
mortise holes.
STEP-V
If the wheels do not rotate after assembly, losen the bolts until you can
achieve a smooth but secure movement.
STEP-VI
Insert screws into all leg braces to secure the legs to
the chaise frame. Do not hammer in the screws, but
drive them in with a proper hand held screw driver.
STEP-VII
With all legs tight against the side rails, insert the locking dowels and drive
them in gently with a hammer. You should place the sanding block
between the hammer and the dowel to prevent marring of the wood. If any
dowels protrude, please do not force them in. Any excess can easily be
sanded away.
IF YOU HAVE ANY QUESTIONS REGARDING THE ASSEMBLY OF YOUR
KINGSLEY-BATE FURNITURE, PLEASE CONTACT THE KINGSLEY-BATE DEALER
NEAREST TO YOU OR KINGSLEY-BATE DIRECTLY. WE THANK YOU FOR
CHOOSING OUR FURNITURE.
*KINGSLEY-BATE WILL NOT TAKE RESPONSIBILITY FOR DAMAGE
IF THESE INSTRUCTIONS ARE NOT FOLLOWED PROPERLY
7200 Gateway Court, Manassas, Virginia 20109
Phone: [phone], Fax: [phone]