kingsley-bate WS-55 User manual

ASSEMBLY INSTRUCTIONS FOR THE WS-55/59
LEG ASSEMBLY
BOTTOM STRETCHER TABLE TOP
NOTE:
A TENON
B MORTISE HOLE
STEP-I
Unpack, inspect and lay the parts on a clean, flat, soft surface to
avoid marring the wood.
NOTE: During assembly of the furniture please match all joints with the corresponding letters
or numbers stamped on the furniture. This is a two person project.
STEP-II
With the table top
upside down on a
clean, smooth
surface, fit one
LEG ASSEMBLY
mortise holes onto the TABLE TOP tenons as shown in the photographs. If necessary, gently
rock the LEG ASSEMBLY while pushing tenons into the mortise holes until joints fit snugly
(use of a rubber mallet may be needed). Again, matching the numbers stamped on the tenons
with the mortise holes, fit the BOTTOM STRETCHER as shown in the photograph (please
note there is a top and bottom side to the BOTTOM STRETCHER). While holding BOTTOM
STRETCHER in place, fit the second LEG ASSEMBLY, as shown in photographs. If you
need to use a rubber mallet to drive the joints together you should have one person on either
side of the table; one to keep the parts from sliding on your smooth surface or shifting left to
right, the other to drive the joints.

STEP-III
Carefully hammer the
dowels into the pre-drilled
holes of the assembly and
secure the screws with a
proper hand held
screwdriver to the underside apron of the LEG ASSEMBLIES, details are shown in the
photographs.
NOTE: DO NOT FORCE THE DOWELS; ANY EXCESS CAN EASILY BE SANDED
AWAY. IF THE DOWELS ARE NOT FLUSH DO NOT CONTINUE TO DRIVE THE
DOWELS, YOU MIGHT DAMAGE THE ITEM. USE OF A POWER
SCREWDRIVER IS NOT RECOMMENDED. THE TORQUE OF A POWER
SCREWDRIVER CAN EASILY STRIP THE SCREW HOLE.
NOTE: TO UPRIGHT THE TABLE LIFT STRAIGHT UP, ROTATE IN THE AIR
AND SET IT BACK DOWN. ROLLING THE TABLE OVER MAY CAUSE
DAMAGE TO THE ITEM.
IF YOU HAVE ANY QUESTIONS REGARDING THE ASSEMBLY OF YOUR
KINGSLEY BATE FURNITURE, PLEASE CONTACT KINGSLEY BATE CUSTOMER
SERVICE AT 703-361-7000. WE THANK YOU FOR CHOOSING OUR FURNITURE.
*KINGSLEY BATE WILL NOT TAKE RESPONSIBILITY FOR DAMAGE
IF THESE INSTRUCTIONS ARE NOT FOLLOWED PROPERLY.
7200 Gateway Court, Manassas, Virginia 20109
Phone: [phone], Fax: [phone]