kingsley-bate Essex TR37 User manual

Kingsley-Bate
TR37 Essex 36" Round Bar Table
Assembly Instructions

KINGSLEY – BATE
Fine Garden Furniture
0ASSEMBLY INSTRUCTIONS FOR THE TR - 37
LEGS TABLE TOP BASE
1STEP-I
Unpack, inspect and lay the parts on a clean, flat, soft surface to avoid
marring the wood.
NOTE: During assem bly of the furn iture please match all joints with
the corresponding letters or numbers stamped on the furniture.
2*NOTE:
8A TENON
9B MORTISE HOLE
3STEP-II
Place the TABLE TOP face down and carefully insert the LEG tenon s
into their respective mortise holes on the underside of the TABLE TOP.
Tenons of the LEGS will be stam ped with a num ber or letter to
correspond with their respective mortise holes on the BASE.
4STEP-III
Carefully take the BASE and insert the LEG tenons
into their respective m ortise holes. Again, please be
sure to line up the stam ped numbers or letters. Using
a rubber mallet or a regular hammer with a wood
block between the hammer and the wood, drive the
tenons and m ortise holes toge ther until all the joi nts
fit snugly together. Drive the wooden dowels through
the tenons of the LEGS using direct sharp bl ows from a hammer. To avoid m arring the
wood please use a block of wood between the dowel head and the hammer head for t he
last few blows. Do not force dowels; any excess can easily be sanded away.

5STEP-IV
Drive the remaining dowels into the BASE using the same care used
in STEP III. Again, do not force the dowels. An y excess can easily
be sanded away.
6STEP-V
Insert all screws into pre-drilled hol es using a proper screw d river as
shown in the diagram.
7STEP-VI
Place the table upright and insert all screws into pre-drilled holes
using a proper screw driver as shown in the diagram. Cover the screw
holes with the teak plugs provided. Tap them in carefully with a
hammer.
IF YOU HAVE ANY QUES TIONS REGARDING THE ASSEMBLY OF YOUR
KINGSLEY-BATE FURNITURE, PLEASE CONTACT THE KINGSLEY-BATE
DEALER NEAREST TO YOU OR KINGSLEY-BATE DIRECTLY. WE THANK YOU
FOR CHOOSING OUR FURNITURE.
*KINGSLEY-BATE WILL NOT TAKE RESPONSIBILITY FOR DAMAGE IF THESE
INSTRUCTIONS ARE NOT FOLLOWED PROPERLY.
7200 Gateway Court, Manassas, Virginia 20109
Phone: [phone], Fax: [phone]