Liko Viking XL User manual

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 31 www.hill-rom.com lwww.liko.com
Overhead Beam Restoration set
Renoveringssats lyftarm
Assembly Instruction
Monteringsanvisning
Prod. No. 20490008
3SE630228-06
2011-03-03
© Copyright Liko AB www.liko.com
Tools required:
5.197
10 mm
2X
M6x60
M6x75
M6x50
Bearing
Mob.50
Bearing
Mob.38
Bearing
Mob.62
Contains: Qty:
Plastic cover mast Viking 2
Cap Y Viking 2
Cap I Viking 2
Cover hat Liko & bottom 6
Sleeve bearing Mob.38 1
Sleeve bearing Mob.50 1
Sleeve bearing Mob.62 1
Locking nut M6 Nyloc 3
Screw M6S M6x50 1
Screw M6S M6x60 1
Screw M6S M6x75 1
Washer PS 6x12x1 7
Fits:
Viking XL (Prod. No. 2040003), to S/N 801999
Viking L (Prod. No. 2040004), to S/N 7200794
Viking M (Prod. No. 2040005), to S/N 7106200
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts.
Makesurethebearingsarexedinthese
positions when the arm is mounted.
5.197

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 32 www.hill-rom.com lwww.liko.com
Control Box
Kontrollbox
Assembly Instruction
Monteringsanvisning
3SE630223-10
2012-08-09
© Copyright Liko AB www.liko.com
Tools required:
NOTE
-
Make sure that the spare part is approved for the lift, and that it is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts.
3 mm
For other markets:
Spare Part No:
20090022, 20190014, 20190076, 20290011, 20290024, 20390007*, 20490009, 20490013
Contains: Qty:
Control Box 1
Extension cable 1
Part No. Fits:
20090022,
20090022US
Golvo 7000ES / 7007ES, 7007 LowBase
20190014,
20190014US
Uno 102 ES
20190076,
20190076US
Uno 100 EM/EE
Uno 102 EM/EE
20290011,
20290011US
Sabina EM/EE
20290024,
20290024US
Sabina II EM/EE
20390007 LikoLight (*Spare part without extension cable)
20490009,
20490009US
Viking XL (Prod. No. 2040003)
Viking L (Prod. No. 2040004)
20490013,
20490013US
Viking M (Prod. No. 2040005)
Let’s meet and discuss the compability problem we are having on the
CBJ spare part.
The queson to answer is:
What recommendaon do we give customers who are buying a new
control box with the rubber grommet but are having the old shorter
charging cord.
NOTE: Uno 100 EM
Uno 102 EM
Sabina EM
Sabina ll EM
Use plug from the
replaced control box!
For the North American market
Spare Part No:
20090022US, 20190014US, 20190076US, 20290011US, 20290024US, 20390007*, 20490009US, 20490013US
Contains: Qty:
Control Box 1
Extension cable, US 1
NOTE: LikoLight has no extension cable
Extension Cable, US
Skarvkabel, US
Assembly Instruction
Monteringsanvisning
Prod. No. 21090011
3SE630218-02
2007-10-29
© Copyright Liko AB www.liko.com
Assembly Instruction
Monteringsanvisning
1.
3.
Extension Cable, US
Skarvkabel, US Prod.no: 21090011
Doc. no:3SE630218-01
2005-10-25
5.263.1
2.
5.263.1
5.198

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 33 www.hill-rom.com lwww.liko.com
Locking Handle Viking XL
Låsvred Viking XL
Assembly Instruction
Monteringsanvisning
Prod. No. 20490010
3SE630244-03
2009-06-26
© Copyright Liko AB www.liko.com
Tools required:
5.199.1
Place locking handle in lower hole and tighten.
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts.
Contains: Qty:
Lever M10 grey 1
Lever M10x85 grey 1
Fits:
Viking XL
Viking L
Viking M
Viking XS
5.199

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 34 www.hill-rom.com lwww.liko.com
Extension Cable, US
Skarvkabel, US
Assembly Instruction
Monteringsanvisning
Prod. No. 21090011
3SE630218-06
2011-05-02
© Copyright Liko AB www.liko.com
5.263
Contains: Qty:
Extension cable US 1
Fits:
Golvo 7000ES/7007ES
Golvo 7007 LowBase
Uno 100 EM/EE
Uno 102 EM/EE/ES
Sabina EM/EE
Sabina II EM/EE
Viking XL Prod. No. 2040003
Viking L Prod. No. 2040004
Viking M Prod. No. 2040005
Length 26.5 cm/ 10.5 inch
Extension Cable, US
Skarvkabel, US
Assembly Instruction
Monteringsanvisning
Prod. No. 21090011
3SE630218-02
2007-10-29
© Copyright Liko AB www.liko.com
Assembly Instruction
Monteringsanvisning
1.
3.
Extension Cable, US
Skarvkabel, US Prod.no: 21090011
Doc. no:3SE630218-01
2005-10-25
5.263.1
2.
5.263.1
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
-
Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts.
5.263

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 35 www.hill-rom.com lwww.liko.com
Safety Latch Universal Slingbar
Urkrokningsskydd Universalbygel
Assembly Instruction
Monteringsanvisning
Prod. No. 31590011
3SE630229-03
2009-12-01
© Copyright Liko AB www.liko.com
5.264.1
Contains: Qty:
Safety latch 2
Fits:
3156074 Universal SlingBar 350
3156075 Universal SlingBar 450
3156076 Universal SlingBar 600
3156077 Universal TwinBar 670
3156079 Universal SideBars 450
3156084 Universal SlingBar 350 with Quick-release Hook
3156085 Universal SlingBar 450 with Quick-release Hook
3156086 Universal SlingBar 600 with Quick-release Hook
3156087 Universal TwinBar 670 with Quick-release Hook
3156094 Universal SlingBar 350 R2R
3156095 Universal SlingBar 450 R2R
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts.
5.264

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 36 www.hill-rom.com lwww.liko.com
Hook for HandControl 2, 4, 6 button
Krok för handkontroll 2, 4, 6 knappar
Assembly Instruction
Monteringsanvisning
Prod. No. 20090058
3SE630210-06
2012-10-16
© Copyright Liko AB www.liko.com
Tools required:
5.292
T10
Contains: Qty:
Hook for Hand control 2,4,6 1
Fits:
20090089 HandControl 6-button
20190016 HandControl EE 4-button
20190017 HandControl EM 2 button
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts.
5.292

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 37 www.hill-rom.com lwww.liko.com
© Copyright Liko AB, 2014 May www.liko.com
Tools required:
5.293
End Cover Handle/Arm Support, grey
Ändplugg handtag/armstöd, grå
Assembly Instruction
Monteringsanvisning
Prod. No. 20090066
3SE630271 Rev 2
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts.
Contains: Qty:
End Cover, grey 4
Fits: Prod. No.
Golvo 7000 ES 2000009
Golvo 7007 ES 2000010
Golvo 7007 Lowbase 2000061
Golvo 8000 2000014, 2000034
Golvo 8008 2000015, 2000035
Golvo 8008 Lowbase 2000015, 2000039
LikoLight
Viking XL
Viking L
Viking M
Viking S
Viking XS
RollOn

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 38 www.hill-rom.com lwww.liko.com
Lift Arm Plastic Cover
Pelarkåpa
Assembly Instruction
Monteringsanvisning
Prod. No. 20490023
3SE630250-07
2012-08-22
© Copyright Liko AB www.liko.com
Tools required:
10 mm
2x
5.307
Contains: Qty:
A Cover hat Liko 2
B Screw M6S M6x75 1
C Washer PS 6x12x1 3
D Cover hat Liko bottom 2
E Flanged washer 2
F Distance washer PS 12x18x1 2
G Plastic cover mast Vi XS 2
H Sleeve bearing Mob.62 1
I Locking nut M6 Nyloc 1
Fits: Prod. No.
Viking XL 2040003 from S/N 802000
Viking XL 2040013
Viking XL 2040033
Viking L 2040004 from S/N 7200795
Viking L 2040014
Viking L 2040034
Viking M 2040005 from S/N 7106201
Viking M 2040015
Viking M 2040035
Viking XS 2040007
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts.
ABCDEFG
HF
ECA
I
D
5.307

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 39 www.hill-rom.com lwww.liko.com
Overhead Beam Restoration set
Renoveringssats lyftarm
Assembly Instruction
Monteringsanvisning
Prod. No. 20490024
3SE630251-08
2012-09-10
© Copyright Liko AB www.liko.com
5.308
Pos Contains: Qty:
ACap Y Viking 2
B Cap I Viking 2
C Cover hat Liko 6
D Cover hat Liko bottom 6
E Sleeve bearing Mob.38 1
F Sleeve bearing Mob.50 1
G Sleeve bearing Mob.62 1
H Plastic cover mast Vi XS 2
I Nylon bearing 10/12x15 2
J Locking nut M6 Nyloc 3
K Distance washer PS 12x18x1 2
L Screw M6S M6x50 1
M Screw M6S M6x60 1
N Screw M6S M6x75 1
O Washer PS 6x12x1 6
P Flanged washer 2
Fits: Prod. No.
Viking XL 2040003 from S/N 802000
Viking XL 2040013
Viking XL 2040033
Viking L 2040004 from S/N 7200795
Viking L 2040014
Viking L 2040034
Viking M 2040005 from S/N 7106201
Viking M 2040015
Viking M 2040035
Viking XS 2040007
1. 2.
3.
Tools required:
10 mm
2x
H
PK
KP
H
1.
Viking XS
CNOD
O
DJC
G

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 40 www.hill-rom.com lwww.liko.com
Overhead Beam Restoration set
Renoveringssats lyftarm
Assembly Instruction
Monteringsanvisning
Prod. No. 20490024
© Copyright Liko AB www.liko.com
Pos Contains: Qty:
ACap Y Viking 2
B Cap I Viking 2
C Cover hat Liko 6
D Cover hat Liko bottom 6
E Sleeve bearing Mob.38 1
F Sleeve bearing Mob.50 1
G Sleeve bearing Mob.62 1
H Plastic cover mast Vi XS 2
I Nylon bearing 10/12x15 2
J Locking nut M6 Nyloc 3
K Distance washer PS 12x18x1 2
L Screw M6S M6x50 1
M Screw M6S M6x60 1
N Screw M6S M6x75 1
O Washer PS 6x12x1 6
P Flanged washer 2
Viking M
Viking XS Viking XL
Viking L
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts.
C
2. Viking M, L, XL
J O D E D O L C
3.
CMDFDOJC
BA
AB
2. Viking XS
CLODEDOLC
II
5.308

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 41 www.hill-rom.com lwww.liko.com
Actuator Viking XL
Ställdon Viking XL
Assembly Instruction
Monteringsanvisning
Prod. No. 20490025
3SE640241-06
2011-03-03
© Copyright Liko AB www.liko.com
Tools required:
5.309.1
2X 10mm
or
2X 17 mm
Old version
From S/N 802000 Viking XL
From S/N 7200795 Viking L
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts.
Contains: Qty:
Outer Tube 1
Locking nut M10 Nyloc 2
Locking nut M6 Nyloc 2
Actuator Viking XL 1
Fits:
Viking XL Prod. No. 2040003
Viking L Prod. No. 2040004
5.309

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 42 www.hill-rom.com lwww.liko.com
5.311.1
Latch, composite
Urkrokningsskydd komposit
Assembly Instruction
Monteringsanvisning
Prod. No. 31590014
3SE640242-05
2011-02-22
© Copyright Liko AB www.liko.com
5.311
The Latch can only be used on
composite hooks equipped with a
locator.
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts.
Contains: Qty:
Latch composite 2
Fits: From S/N:
3156074 Universal SlingBar 350 1299511
3156075 Universal SlingBar 450 1299511
3156076 Universal SlingBar 600 1299511
3156077 Universal TwinBar 670 1299511
3156079 Universal SideBars 450 1299511
3156084 Universal SlingBar 350 with Quick-release Hook 1299511
3156085 Universal SlingBar 450 with Quick-release Hook 1299511
3156086 Universal SlingBar 600 with Quick-release Hook 1299511
3156087 Universal TwinBar 670 with Quick-release Hook 1299511
3156094 Universal SlingBar 350 R2R 1299511
3156095 Universal SlingBar 450 R2R 1299511
20590006 SlingBar Liko 450 1700101

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 43 www.hill-rom.com lwww.liko.com
Outer Tube
Skyddsrör
Assembly Instruction
Monteringsanvisning
Prod. No. 20490030
3SE640260-05
2011-03-03
© Copyright Liko AB www.liko.com
Tools required:
5.331.1
2. 3.
6.
10 mm
2x
1.
2 mm
Lock
10 mm
Isopropyl alcohol and water + rag
5.
4.
Before fastening the snap bushing
Clean marked area with 50/50
Isopropyl alcohol and water.
Remove the tape cover!
120mm (4,7 inch)
100mm (3,9
inch)
132±5mm
(5,2
a
b
d
c
e
f
b
g
hold
Contains: Qty:
a Top cover 1
b Screw P6SS M4x5 6
c Tube 1
d Snap bushing 2
e Two sided adhesive 2
f Bushing 1
g Compression spring 1
Fits:
Viking M
Viking L Prod. No. 2040004
Viking XL Prod. No. 2040003
5.331

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 44 www.hill-rom.com lwww.liko.com
Outer Tube
Skyddsrör
Assembly Instruction
Monteringsanvisning
Prod. No. 20490030
3SE640260-05
2011-03-03
© Copyright Liko AB www.liko.com
Tools required:
5.331.2
7.
13.
8.
10.
The three screws should be tight-
ened until ush with surface of tube.
Make sure the Outer Tube easy
slides up and down.
12.
11.
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts.
9.
5.331

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 45 www.hill-rom.com lwww.liko.com
Wireless Handcontrol HBL 20
Handkontroll IR HBL20
Assembly Instruction
Monteringsanvisning
Prod. No. 20490031
3SE640298-04
2011-03-03
© Copyright Liko AB www.liko.com
Tools required:
132 mm / 5 inch
2.
A. To activate IR control: Hold the hand
control IR about 20 cm/0.8 inch. from the
control unit’s IR receiver and press the
large UP and DOWN buttons on the hand
control simultaneously for about 2 seconds.
A signal is heard when the function is
activated. The lift is now ready to use with
Handcontrol IR.
B. Check to determine if other lifts in the
room are affected by your hand control. If
other lifts are affected by your hand control:
Use the large UP and DOWN buttons on
the operation panel of the lift that is to be
used. Press both buttons simultaneously
until a signal sounds. The lift has now been
assigned a unique communication code.
Now, activate IR control according to proce-
dure A, above.
4. 5.
Choice
1.
/
Contains: Qty:
Handcontrol HBL20 1
Clips with hook HBL20 1
Charge Cable Hook 2
Fits:
Golvo 8000 / 8008
Viking M Prod. No. 2040015
Viking L Prod. No. 2040014
Viking XL Prod. No. 2040013
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts.
50 mm / 2 inch
3. Golvo Viking M, Viking L, Viking XL
5.333
5.333

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 46 www.hill-rom.com lwww.liko.com
Control Unit CBL, by S/N
Kontrollbox CBL S/N-styrd
Assembly Instruction
Monteringsanvisning
Prod. No. 20490039
3SE650270-03
2012-10-24
© Copyright Liko AB www.liko.com
Tools required:
2,5 mm
3 mm
Contains: Qty:
Control Unit CBL20 1 (pre-congured)
Cable cover 1
Screw cable cover 2
Screw M5x35 2 (Viking)
Screw M5x50 2 (Golvo)
Allen Key 2,5 mm 1
Fits: Prod. No.
Viking XL 2040013
Viking L 2040014
Viking M 2040015
Golvo 8008 LowBase 2000019
Golvo 8000 2000014
Golvo 8008 2000015
Golvo 8000 Classic 2000024
Golvo 8008 Classic 2000025
2. 3. 4.
5.
Before use!
Make sure the
S/N on the label
on Control
Unit CBL is the
same as on the
lift.
1.
50 mm
Centre laterally
Centrera i sidled
Controlbox CBL20
Prod.No 20490032
onlyfor use with:
VikingM
Prod.No 2040015
Etikettstorlek:52 X 21 mm
Layout?
Viking M:
The lower holes.
(no choice on the
Viking L & XL)
6. Viking: Golvo:
4 mm
5.336
ConformstoISO10535:2006withANSI/AAMIES60601-1:2005and
iscertifiedtoISO10535:2006withCSA-C22.2No.60601-1:08.
Int.Op:10/90Activetime2min.
?=;;;;æ;æ;–;æ;æ?æ=ƒ;æ:æ;+÷+‹;:æ;æ;æ;:æ;:æ;:æ;:æ;:æ;„*„.æ;æ?=
?=;;;;Ó;Ó;–;æ;æ?æ=ƒ;æ:æ;+÷+‹;:æ;Ó;Ó;:æ;:æ;:æ;:æ;:æ;„*„.Ó;Ó?=
7;;;;;;;330925;;;;;000001;;;<
;;;;;;;ƒ;æ;;;;æ;–;;æ;;ƒ;;ƒ;ƒ;;ƒ;;æ;;;æ;–;;;;æ;ƒ;;;æ;ƒ=ƒ=;æ;ƒ;;;;;;;
;;;;;;;ƒ;æ;;;;æ;–;;æ;;ƒ;;ƒ;ƒ;;ƒ;;æ;;;æ;–;;;;æ;ƒ;;;æ;ƒ=ƒ=;æ;ƒ;;;;;;;
;;;;;;8301209
24 V DC - 2.2 AhIP54 IEC 60601-1
TESTED
EAN-13Serial.no.
Y/M : 2012-3
Maxxxxkg/ xxx lbs
9801154
Productname
Prod. No.1234567
www.liko.com
Liko AB, Nedre vägen 100, 975 92 Luleå, Sweden
Conformsto ISO 10535:2006 with ANSI/AAMI ES60601-1:2005 and
iscertified to ISO 10535:2006 with CSA- C22.2 No. 60601-1:08.
Int.Op: 10/90 Active time 2 min.
?=;;;;æ;æ;–;æ;æ?æ=ƒ;æ:æ;+÷+‹;:æ;æ;æ;:æ;:æ;:æ;:æ;:æ;„*„.æ;æ?=
?=;;;;Ó;Ó;–;æ;æ?æ=ƒ;æ:æ;+÷+‹;:æ;Ó;Ó;:æ;:æ;:æ;:æ;:æ;„*„.Ó;Ó?=
7;;;;;;;330925;;;;;000001;;;<
;;;;;;;ƒ;æ;;;;æ;–;;æ;;ƒ;;ƒ;ƒ;;ƒ;;æ;;;æ;–;;;;æ;ƒ;;;æ;ƒ=ƒ=;æ;ƒ;;;;;;;
;;;;;;;ƒ;æ;;;;æ;–;;æ;;ƒ;;ƒ;ƒ;;ƒ;;æ;;;æ;–;;;;æ;ƒ;;;æ;ƒ=ƒ=;æ;ƒ;;;;;;;
;;;;;;8301209
24 V DC - 2.2 Ah IP54 IEC 60601-1
TESTED
EAN-13Serial.no.
Y/M : 2012-3
Max xxx kg / xxx lbs
9801154
Product name
Prod. No. 1234567
www.liko.com
Liko AB, Nedre vägen 100, 975 92 Luleå, Sweden
S/N:
!
TAGBORTTRANSPORTSTÖDMED
SKRUVARFÖREMONTERING.
BEFOREASSEMBLINGREMOVE
TRANSPORTSAFETYBRACKET.
VORDEMAUFSTELLENTRANSPORT-
SICHERUNGENTFERNEN.
AVANTASSEMBLAGE,DÉMONTER
LASÉCURITÉDETRANSPORT.
?=;;;;æ;æ;–;æ;æ?æ=ƒ;æ:æ;+÷+‹;:æ;æ;æ;:æ;:æ;:æ;:æ;:æ;„*„.æ;æ?=
?=;;;;Ó;Ó;–;æ;æ?æ=ƒ;æ:æ;+÷+‹;:æ;Ó;Ó;:æ;:æ;:æ;:æ;:æ;„*„.Ó;Ó?=
7;;;;;;;330925;;;;;000001;;;<
;;;;;;;ƒ;æ;;;;æ;–;;æ;;ƒ;;ƒ;ƒ;;ƒ;;;æ;;æ;–;;;ƒ;;æ=;ƒ;ƒ=;æ;ƒ;;;;;;;
;;;;;;;ƒ;æ;;;;æ;–;;æ;;ƒ;;ƒ;ƒ;;ƒ;;;æ;;æ;–;;;ƒ;;æ=;ƒ;ƒ=;æ;ƒ;;;;;;;
;;;;;;8301217
24 V DC - 2.2 AhIPX4 IEC 60601-1
TESTED
EAN-13
Serial.no.
Y/M : 2012-6
Maxxxxkg/xxx lbs
9801154
Productname
Prod. No.1234567
www.liko.com
Liko AB, Nedre vägen 100, 975 92 Luleå, Sweden
ConformstoISO10535:2006withANSI/AAMI
ES60601-1:2005andiscertifiedto
ISO10535:2006withCSA-C22.2No.60601-1:08.
Int.Op:10/90Activetime2min.
Viking Golvo
M5x35 M5x50
5.336

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 47 www.hill-rom.com lwww.liko.com
Control Unit CBL, by S/N
Kontrollbox CBL S/N-styrd
Assembly Instruction
Monteringsanvisning
Prod. No. 20490039
© Copyright Liko AB www.liko.com
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts.
A. To activate IR control: Hold the hand control
IR about 20 cm/0.8 inch. from the control unit’s
IR receiver and press the large UP and DOWN
buttons on the hand control simultaneously for
about 2 seconds. A signal is heard when the
function is activated. The lift is now ready to
use with Hand control IR.
B. Check to determine if other lifts in the room
are affected by your hand control. If they are:
Use the large UP and DOWN buttons on the
operation panel of the lift that is to be used.
Press both buttons simultaneously until a
signal sounds. The lift has now been assigned
a unique communication code. Now, activate
IR control according to procedure A, above.
/
8.
5.336
- Charger cable; socket 1
- Lift motor cable; socket 2
- Base-motor cable; socket 3
1
3
”click”
7.
2
5.336

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 48 www.hill-rom.com lwww.liko.com
Control Unit CBL, by S/N, Cable
Kontrollbox CBL S/N-styrd, kabel HK
Assembly Instruction
Monteringsanvisning
Prod. No. 20490054
3SE690227-02
2013-01-31
© Copyright Liko AB www.liko.com
Tools required:
5.336C
2,5 mm
(provided)
3 & 4mm
2. 3. 4.
5.
Before use!
Make sure the
S/N on the label
on Control
Unit CBL is the
same as on the
lift.
1.
Viking M:
The lower holes.
(no choice on the
Viking L & XL)
6. Viking: Golvo:
ConformstoISO10535:2006withANSI/AAMIES60601-1:2005and
iscertifiedtoISO10535:2006withCSA-C22.2No.60601-1:08.
Int.Op:10/90Activetime2min.
?=;;;;æ;æ;–;æ;æ?æ=ƒ;æ:æ;+÷+‹;:æ;æ;æ;:æ;:æ;:æ;:æ;:æ;„*„.æ;æ?=
?=;;;;Ó;Ó;–;æ;æ?æ=ƒ;æ:æ;+÷+‹;:æ;Ó;Ó;:æ;:æ;:æ;:æ;:æ;„*„.Ó;Ó?=
7;;;;;;;330925;;;;;000001;;;<
;;;;;;;ƒ;æ;;;;æ;–;;æ;;ƒ;;ƒ;ƒ;;ƒ;;æ;;;æ;–;;;;æ;ƒ;;;æ;ƒ=ƒ=;æ;ƒ;;;;;;;
;;;;;;;ƒ;æ;;;;æ;–;;æ;;ƒ;;ƒ;ƒ;;ƒ;;æ;;;æ;–;;;;æ;ƒ;;;æ;ƒ=ƒ=;æ;ƒ;;;;;;;
;;;;;;8301209
24VDC-2.2 Ah IP54IEC60601-1
TESTED
EAN-13Serial.no.
Y/M:2012-3
Maxxxxkg/ xxx lbs
9801154
Productname
Prod.No.1234567
www.liko.com
LikoAB,Nedrevägen100,97592Luleå, Sweden
Conformsto ISO 10535:2006 with ANSI/AAMI ES60601-1:2005 and
iscertified to ISO 10535:2006 with CSA- C22.2 No. 60601-1:08.
Int.Op: 10/90 Active time 2 min.
?=;;;;æ;æ;–;æ;æ?æ=ƒ;æ:æ;+÷+‹;:æ;æ;æ;:æ;:æ;:æ;:æ;:æ;„*„.æ;æ?=
?=;;;;Ó;Ó;–;æ;æ?æ=ƒ;æ:æ;+÷+‹;:æ;Ó;Ó;:æ;:æ;:æ;:æ;:æ;„*„.Ó;Ó?=
7;;;;;;;330925;;;;;000001;;;<
;;;;;;;ƒ;æ;;;;æ;–;;æ;;ƒ;;ƒ;ƒ;;ƒ;;æ;;;æ;–;;;;æ;ƒ;;;æ;ƒ=ƒ=;æ;ƒ;;;;;;;
;;;;;;;ƒ;æ;;;;æ;–;;æ;;ƒ;;ƒ;ƒ;;ƒ;;æ;;;æ;–;;;;æ;ƒ;;;æ;ƒ=ƒ=;æ;ƒ;;;;;;;
;;;;;;8301209
24 V DC - 2.2 Ah IP54 IEC 60601-1
TESTED
EAN-13Serial.no.
Y/M : 2012-3
Max xxx kg / xxx lbs
9801154
Product name
Prod. No. 1234567
www.liko.com
Liko AB, Nedre vägen 100, 975 92 Luleå, Sweden
S/N:
!
TAGBORTTRANSPORTSTÖDMED
SKRUVARFÖREMONTERING.
BEFOREASSEMBLINGREMOVE
TRANSPORTSAFETYBRACKET.
VORDEMAUFSTELLENTRANSPORT-
SICHERUNGENTFERNEN.
AVANTASSEMBLAGE,DÉMONTER
LASÉCURITÉDETRANSPORT.
?=;;;;æ;æ;–;æ;æ?æ=ƒ;æ:æ;+÷+‹;:æ;æ;æ;:æ;:æ;:æ;:æ;:æ;„*„.æ;æ?=
?=;;;;Ó;Ó;–;æ;æ?æ=ƒ;æ:æ;+÷+‹;:æ;Ó;Ó;:æ;:æ;:æ;:æ;:æ;„*„.Ó;Ó?=
7;;;;;;;330925;;;;;000001;;;<
;;;;;;;ƒ;æ;;;;æ;–;;æ;;ƒ;;ƒ;ƒ;;ƒ;;;æ;;æ;–;;;ƒ;;æ=;ƒ;ƒ=;æ;ƒ;;;;;;;
;;;;;;;ƒ;æ;;;;æ;–;;æ;;ƒ;;ƒ;ƒ;;ƒ;;;æ;;æ;–;;;ƒ;;æ=;ƒ;ƒ=;æ;ƒ;;;;;;;
;;;;;;8301217
24VDC-2.2Ah IPX4 IEC60601-1
TESTED
EAN-13
Serial.no.
Y/M:2012-6
Maxxxxkg/xxx lbs
9801154
Productname
Prod.No.1234567
www.liko.com
LikoAB,Nedrevägen100,97592Luleå,Sweden
ConformstoISO10535:2006withANSI/AAMI
ES60601-1:2005andiscertifiedto
ISO10535:2006withCSA-C22.2No.60601-1:08.
Int.Op:10/90Activetime2min.
Viking Golvo
M5x35 M5x50
Contains: Qty:
Control Unit CBL20, cable 1 (pre-congured)
Cable cover 1
Screw, cable cover 2
Screw M5x35 2 (Viking)
Screw M5x50 2 (Golvo)
Allen Key 2,5 mm 1
Fits: Prod. No.
Viking XL 2040033
Viking L 2040034
Viking M 2040035
Golvo 8008 LowBase 2000039
Golvo 8000 2000034
Golvo 8008 2000035
Controlbox CBL20
Prod.No 20490032
onlyfor use with:
VikingM
Prod.No 2040015
Etikettstorlek:52 X 21 mm
Layout?

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 49 www.hill-rom.com lwww.liko.com
© Copyright Liko AB www.liko.com
Control Unit CBL, by S/N, Cable
Kontrollbox CBL S/N-styrd, kabel HK
Assembly Instruction
Monteringsanvisning
Prod. No. 20490054
3SE690227-02
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts.
5.336C
- Charger cable; socket 1
- Lift motor cable; socket 2
- Base-motor cable; socket 3
9.
1
3
”click”
8.
2
Attach the locking ring.
Connect the Hand control. Make sure the rectangular tabs
at the locking ring are xed.
Battery
Prod. No. 2006107
Triangular tab
facing out.

Service Manual Viking™XL mobile lift • 3EN350401 Rev. 10 50 www.hill-rom.com lwww.liko.com
Extension cable CBL20
Skarvkabel CBL20
Assembly Instruction
Monteringsanvisning
Prod. No. 21090018 Extension cable CBL20
21090019 Extension cable CBL20, US
3SE650216-05
2012-09-11
© Copyright Liko AB www.liko.com
Tools required:
Connect the Charging cable to the Extension cable and
the Extension cable to the wall socket (100-240 V AC).
The battery is fully charged after 5 hours.
After completed charging, place the cable on the
Charge cable hook.
2,5 mm
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts.
Contains: Qty:
Adapter cable charging 1
Extension Cable, US
Skarvkabel, US
Assembly Instruction
Monteringsanvisning
Prod. No. 21090011
3SE630218-03
2009-11-13
© Copyright Liko AB www.liko.com
5.263.1
NOTE
- Make sure the spare part is mounted according to the assembly instruction.
- Check all functions related to the changed spare part.
- Repairs and maintenance may only be performed by personnel authorized by Liko and using original Liko spare parts.
Contains: Qty:
Extension cable US 1
Fits:
Golvo 7000ES/7007ES
Uno 100 EM/EE
Uno 102 EM/EE/ES
Sabina EM/EE
Sabina II EM/EE
Viking XL
Viking L
Viking M (prod. no. 2040005)
Length 26.5 cm/ 10.5 inch
Extension Cable, US
Skarvkabel, US
Assembly Instruction
Monteringsanvisning
Prod. No. 21090011
3SE630218-02
2007-10-29
© Copyright Liko AB www.liko.com
1.
3.
2.
5.263.1
Fits: Prod. No:
Golvo 8000/8008 (all models)
Viking XL 2040013 and 2040033
Viking L 2040014 and 2040034
Viking M 2040015 and 2040035
5.348-349