Polaris 2880325 User manual

P/N 9925259 Rev 01 05/14 Page 1 of 3
P/N 2880325
TRAILERABLE COVER KIT
APPLICATION
RZR 900
TOOLS NEEDED
Safety Goggles
KIT CONTENTS
Ref Qty Part Description Part Number
1 1 Trailerable Cover 2880325
1 Instructions 9925259
APPROXIMATE ASSEMBLY TIME
5 mins
BEFORE YOU BEGIN
Read these instructions twice and check to be sure all parts and tools are accounted for. Please retain these
installation instructions for future reference and parts ordering information.
IMPORTANT
Your Polaris TRAILERABLE COVER KIT is exclusively designed for your vehicle. Please read the installation
instructions thoroughly before beginning. Installation is easier if the vehicle is clean and free of debris. For
your safety, and to ensure a satisfactory installation, perform all installation steps correctly in the sequence
shown.
1

P/N 9925259 Rev 01 05/14 Page 2 of 3
INSTALLATION INSTRUCTIONS
1. Place the vehicle in “PARK” and turn
the key to “OFF” position. Remove the
key from the vehicle.
2. If a spare tire is in place, remove the
tire and the tie down clamp before
using the cover to trailer.
3. Stow ratchet (A) by connecting the
Velcro on the ratchet webbing to the
Velcro on the cover as shown in gure.
6. Thread rear webbing (C) through loop
(D) in the back and into the ratchet.
Roll ratchet (A) three fourths of the way
and pull snug as shown in gure.
4. Drape the cover over the vehicle.
5. Attach the front buckle (B) as shown in
gure.
A
B
C
D
A

P/N 9925259 Rev 01 05/14 Page 3 of 3
7. Pull cover down as far as possible
down over all four tires as shown in
gure.
8. Ratchet webbing tight. Guide webbing
into spool. Apply about 10-15 ft. lbs.
(13.5-20 Nm) of pressure on the handle.
9. Attach the male buckle (E) of the center
strap to the female buckle sewn to the
cover. Feed the webbing underneath
the machine and connect the buckles
on the opposite side. Cinch tight by
pulling any excess slack underneath
the footwells as shown in gure.
WARNING:
Ensure the cover is adequately tensioned prior to trailering the unit.
Never trailer covered unit in excess of the speed limit.
Trailer the covered unit in a forward facing direction ONLY.
E