Polaris 2879373 User manual

-1-
Before you begin, read these instructions twice and check to be sure all parts and tools are accounted for. Please
retain these installation instructions for future reference and parts ordering information.
P/N 2879373
IMPORTANT: Your Polaris RZR XP 1000 TRAILERING COVER KIT is exclusively designed for your
vehicle. Please read the installation instructions thoroughly before beginning. Installation is easier
if the vehicle is clean and free of debris. For your safety and to ensure a satisfactory installation,
perform all installation steps correctly in the sequence shown.
TRAILERING COVER KIT
Application
RZR XP 1000
APPROXIMATE ASSEMBLY TIME: 5 minutes
Kit Contents:
Ref Qty Part Description Part Number
1 1 Trailering Cover 2635194
1 Instructions 9924776
1
INSTALLATION INSTRUCTIONS:
1. If a spare tire is in place, remove the tire and the tie
down clamp before using the cover to trailer.
2. Stow ratchet by connecting the Velcro on the
ratchet webbing to the Velcro on the cover.
Figure 1
Stow Ratchet to the
Velcro webbing on
the Cover

-2-
P/N 9924776 Rev 01 08/13
WARNING:
Ensure the cover is adequately tensioned prior to trailering the unit.
Never trailer covered unit in excess of the speed limit.
Trailer the covered unit in a forward-facing direction ONLY.
8. Attach the male buckle of the center strap to the
female buckle sewn to the cover. Feed the webbing
underneath the machine and connect the buckles on
the opposite side. Cinch tight by pulling any excess
slack underneath the footwells. Figure 5.
6. Pull cover down as far as possible down over all
four tires. Figure 4.
7. Ratchet webbing tight. Guide webbing into spool.
Apply about 10-15 ft. lbs. (13.5-20 Nm) of pressure
on the handle.
5. Thread rear webbing through loop in the back and
into the ratchet. Roll ratchet three fourths of the
way and pull snug. Figure 3.
3. Drape the cover over the vehicle.
4. Attach the front buckle. Figure 2.
Figure 2
Figure 3
Figure 4
Figure 5
Front Buckle
Rear Loop
Roll Ratchet
to Tighten
Rear Webbing
Center
Buckle