Sunjoy A101005603 User manual

HDO 10 x 12 Gazebo
Model No.: A101005603
Model UPC: 041226176452
Quality Guaranteed:
If you are not completely satisfied with this product, return it
for refund or replacement.
Comments or questions? 800-697-2448
www.interamericanproducts.com
Distributed by Inter-American Products, Cincinnati, OH 45202

• Pleasereadandunderstandthisentiremanualbeforeattemptingtoassembleorinstalltheproduct.
• Beforebeginningassemblyofproduct,makesureallpartsarepresent.Comparepartswithpackagecontentslist
andhardwarecontentslist.Ifanypartismissingordamaged,donotattempttoassembletheproduct.
• Theassembledgazeboshouldbelocatedatleast6feetfromanyobstructionsuchasfence,garage,house,
overhangingbranches,laundrylinesorelectricalwires.
• Somepartsmaycontainsharpedges.Wearprotectiveglovesifnecessary,duringassembly.
• Checkallnutsandboltsperiodicallyfortightnessand,whenrequired,tightenthemagain.
• Payattentiontothepartsorientation.
• Installthegazeboonlevelground.Stakesareprovidedtosecurethegazebototheground.
• Donotassemblethegazeboonsandy,muddyorloosesoil,asstakesdonothaveenoughanchorageinthesetypes
ofsoil.
• Ifyouwishtosecurethegazebotoawooddeckorconcretesurface,useanchorssuitedtothesesurfaces.
• Snowmustbeclearedoffregularlyduringsnowydays.
• Donotleavethegazebowherethereisariskofhighwind,aspossibledamagewilloccurtothestructure.
• Anyassemblyormaintenanceoftheproductmustbecarriedoutbyadultsonly.
• Pleasecheckyourstateandlocalregulationspriortopurchasing.Somejurisdictionsmayrequirepermitsfor
installationanduse.Somespecialproceduresmaybevalidinyourarea.
•Ifanyscratchpaint,pleasetouchuptopreventrusting.
• Foroutdooruseonly.
GENERALBESTPRACTICESFORASSEMBLY
WARNING
KEEP ALL FLAME AND HEAT SOURCES AWAY FROM THIS TENT FABRIC
THIS TENT IS MADE WITH FLAME RESISTANT FABRIC WHICH MEETS CPAI-84 SPECIFICATIONS. IT IS NOT
FIREPROOF. THE FABRIC WILL BURN IF LEFT IN CONTINUOUS CONTACT WITH ANY FLAME SOURCE. THE
APPLICATION OF ANY FOREIGN SUBSTANCE ON TO THE TENT FABRIC MAY RENDER THE FLAME
RESISTANT PROPERTIES INEFFECTIVE.
WARNINGS

• Steelcomponentsforthisgazeboaretreatedwithrustinhibitingpaintthatprotectsitfromrusting.However,due
tothenatureofsteel,surfaceoxidation(rusting)willoccuriftheseprotectivecoatingsarescratched.Thisisnota
defectandthusnotcoveredbythewarranty.
• Tominimizethiscondition,itisrecommendedtousecarewhenassemblingandhandlingtheproducttoprevent
scratchingthepaint.Shouldanyscratchingordamageoccur,itisrecommendedtocoverthescratchimmediately
withrustinhibitingpaint(notincluded).
•SurfacerustcanalsobeeasilyremovedwithaverylightapplicationofregularcookingoilorWD‐40.Ifsurface
oxidation(rusting)occursandifnomeasureistakentopreventthis,theoxidationmaystartdrippingontodeckor
patioandcauseddamagingstains,whichmaybedifficulttoremove.Thiscanbepreventediftheabove‐mentioned
measuresaretakentokeeptheproductfromoxidizing.
• Donotusebleach,acid,orotherabrasivecleanersontherooforframeparts.
• Keepinstructionmanualforfuturereference.
• Keeptheoriginalpackagingtostorethegazebo.
• Periodicallycheckandensurethatallboltsarewell‐tightenduringuse.
ToolsRecommended(NotIncluded)
Included
MAINTENANCE

ExplodedDrawing




Label PartNumber Description Qty PartImage
A P00020072801 Post  4 
C P006100069 BaseCover 4 
D P000100106 PostBase 4 
E1 P000401043 LongScreen(Left) 2 
E2 P000401044
LongScreen
(Right)
2 
F1 P000401045 ShortScreen(Left) 2 
F2 P000401046
ShortScreen
(Right)
2 
H P000500467 MiddleConnector 4 
I1 P000601822 BigRafter(Upper) 4 
I2 P000601823 BigRafter(Lower) 4 
J1 P000601824 LongJoist(Upper) 2 
J2 P000601826 ShortJoist(Upper) 2 
J3 P000601825 LongJoist(Lower) 2 
J4 P000601827 ShortJoist(Lower) 2 
L P000500465 BigConnector 1 
PartsList



M P000500473 SmallConnector 1 
N P000601821
Rafter(Small
Roof)
4 
O P005800001 Hook 1 
P1 P005700773 LongNettingRod 4 
P2 P005700774 ShortNettingRod 4 
R P001100622 SmallCanopy 1 
S P001100623 BigCanopy 1 
T P001200242 MosquitoNetting 1

U P001300119 Curtain 1 




Label PartNumber Description Qty Spare PartImage
AA H010010003 BoltM6*15 56 3
BB H010010004 BoltM6*35 8 1
CC H050030001 FlatwasherM6 80 4
DD H040010004 NutM6 16 1
EE H070010001 Stake ￠6*230 8 0

FF P005100264 Ring 104 6

Z1 H090010017 WrenchM6 2 0 
HardwarePack






1

























 
2












3