FireplaceXtrordinair PB24 CF Deluxe User manual

PB24 CF Deluxe Log Set - Birch
(sku# 94500619)
Page 1 of 9 17602093 — 2/5/20 © Travis Industries, Inc.
Compatibility
ProBuilder 24 CF Fireplace.
Installation Warnings
NOTE: Consult the installation manual for order of installation. If using propane (LP), convert the appliance
before installing the log set. If using firebacks, install them prior to installing the log set.
The logs are fragile, especially after being exposed to heat.
Make sure the gas control valve is OFF and the heater is cool prior to conducting service.
Failure to position the parts in accordance with these diagrams or failure to use only parts specifically
approved with this appliance may result in property damage or personal injury.
The burner must be correctly positioned before installing the log set. Make sure the burner is fully seated
and the pilot is properly aligned. See owner’s manual for details on burner removal.
Log Set Overview
When installed, the ten (10) logs should appear as shown below.
Log #10
Log #1
Log #8
Log #7
Lo
g
#2
Log #5
Log #9
Log #3
Log #4
Log #6

PB24 CF Deluxe Log Set - Birch
(sku# 94500619)
Page 2 of 9 17602093 — 2/5/20 © Travis Industries, Inc.
Installation
Log #1
Log #1 has two holes that fit over two pins on the back burner (see photos below). Place the log in place and
push it back. The log straddles the burner and does not cover any burner holes.

PB24 CF Deluxe Log Set - Birch
(sku# 94500619)
Page 3 of 9 17602093 — 2/5/20 © Travis Industries, Inc.
Log #2
Log#2 has a groove in the bottom of the left side. The groove fits over a metal ridge on the left end of the bottom
burner. Slide the log backwards until it contacts the sloped portion of the burner. Make sure the log does not
block any burner holes.
Log #3
Log#3 has a groove in the bottom of the right side. The groove fits over a metal ridge on the right end of the
bottom burner. Slide the log backwards until it contacts the sloped portion of the burner. Make sure the log does
not block any burner holes.

PB24 CF Deluxe Log Set - Birch
(sku# 94500619)
Page 4 of 9 17602093 — 2/5/20 © Travis Industries, Inc.
Log #4
Log #4 has (2) channels that align the log with the log grate. Place the log as shown below.
Top View
Front View
Log #5
Place log #5 as shown below. The hole on the bottom of log #5 fits over the pin on Log #4.
Top View
Bottom View

PB24 CF Deluxe Log Set - Birch
(sku# 94500619)
Page 5 of 9 17602093 — 2/5/20 © Travis Industries, Inc.
Log #6
Place log #6 as shown below. The hole on the bottom of log #6 fits over the pin on Log #5. The charred end
points towards the center of the burner.
Top View
Bottom View
Log #7
Place log #7 as shown below. The charred end of log #7 rests on the burner. The right branch has a notch that
aligns the log with the finger of the log grate. The upper end of log #7 rests on a groove in log #3.