kingsley-bate Amalfi AM15 User manual

Kingsley-Bate
AM15 Amalfi Dining Chair
Assembly Instructions

KINGSLEY–BATE
Fine Garden Furniture
0ASSEMBLY INSTRUCTIONS FOR THE AM-15
BACK SEAT
1*NOTE:
8A TENON
9B MORTISE HOLE
10RIGHT END FRAME LEFT END FRAME
2STEP-I
Unpack, inspect and lay the parts on a clean, flat, soft surface to avoid marring the wood.
NOTE: During assembly of the furniture please match all joints with the corresponding letters
or numbers stamped on the furniture.
3STEP-II
Find the END FRAME with num bers stamped next to the m ortise holes
and carefully lay it down. Matching t he numbers, gently slide the BACK
STRETCHER, BOTTOM LEG STRETCHER and the SEAT into place. If
necessary, gently rock the parts while pushing the tenons into the m ortise
holes until joints fit snugly together.
4STEP-III
Carefully fit the remaining END FR AME mortise holes over and ont o the
remaining SEAT, BACK ST RETCHER and BOTTOM LEG
STRETCHER tenons as shown in the assembly photo.
5STEP-IV
Using a hammer, drive the do wels into the END FRAMES
to secure the SEAT and BOTTOM LEG STRETCHER. We
suggest that you use a block of wood between the hammer
and the dowel head for the last few blows. This will reduce
the chances of marring the wood.

6STEP-V
Again, using a hammer, drive the remaining dowels to secure the BACK
STRETCHER to the END FRAMES as seen in the photograph.
7STEP-VI
Carefully slide the BACK into place as
shown in the phot ograph. Secure the
BACK to the BACK STRETCHER by
using a proper screwdriver and the
wood screws provided. Cover the holes
with the teak plugs provided.
NOTE: USE OF A POWER SCREWDRIVE R MAY STRIP THE WOOD, P LEASE USE A
HAND HELD SCREWDRIVER FOR STEP-VI.
STEP-VII
Tip the chair onto its front legs and secure the BACK to the SEAT with the
knock down bolts provi ded. Again, pl ease use a proper screwdriver. A
power screwdriver or a drill with a sc rewdriver bit could cause damage to
the chair. DO NOT FORCE DOWE LS FURTHER THAN THEY WANT
TO GO. Any protruding dowels, can easily be sanded away.
IF YOU HAVE ANY QUESTIONS REGARDING THE ASSEMBLY OF YOUR
KINGSLEY-BATE FURNITURE, PLEASE CONTACT THE KINGSLEY-BATE DEALER
NEAREST TO YOU OR KINGSLEY-BATE DIRECTLY. WE THANK YOU FOR
CHOOSING OUR FURNITURE.
*KINGSLEY-BATE WILL NOT TAKE RESPONSIBILITY FOR DAMAGE IF THESE
INSTRUCTIONS ARE NOT FOLLOWED PROPERLY.
7200 Gateway Court, Manassas, Virginia 20109
Phone: [phone], Fax: [phone]