APRILIA ATLANTIC 500 User manual

use+maintenancebook
ATLANTIC 500
aprilia part# 8104449

2
use and maintenance Atlantic 500
© 2001 aprilia s.p.a. - Noale (VE)
First edition: January 2002
Reprint:
Produced and printed by:
C.L.D. s.r.l. Divisione manualistica tecnica
via D. Alighieri, 37/A - 56012 Fornacette (Pisa)
Tel. +39 - (0)587 42 28 00
Fax +39 - (0)587 42 28 01
www.cld.it
E-mail: [email protected]
On behalf of:
aprilia s.p.a.
via G. Galilei, 1 - 30033 Noale (VE) - Italy
Tel. +39 - (0)41 58 29 111
Fax +39 - (0)41 44 10 54
www.aprilia.com
SAFETY WARNINGS TECHNICAL
The following precautionary warnings are
usedthroughoutthismanualinordertocon-
vey the following messages:
Safety warning. When you find this
symbol on the vehicle or in the
manual, be careful to the potential risk of
personal injury. Non-compliance with the
indications given in the messages pre-
ceded by this symbol may result in grave
risks for your and other people’s safety
and for the vehicle!
Indicates a potential hazard which may
result in serious injury or even death.
Indicates a potential hazard which may
result in minor personal injury or dam-
age to the vehicle.
NOTE The word “NOTE” in this manual
precedes important information or instruc-
tions.
Theoperationsprecededby this sym-
bol must be repeated also on the op-
posite side of the vehicle.
If not expressly indicated otherwise, for the
reassemblyoftheunits repeat thedisassem-
bly operations in reverse order.
The terms “right” and “left” are referred to
the rider seated on the vehicle in the normal
riding position.
Beforestartingtheengine, carefully read this
manual and in particular the section “SAFE
DRIVE”.
Your and other people’s safety depends not
only on your quickness of reflexes and on
youragility,butalsoon what you know about
the vehicle, on its efficiency and on your
knowledgeofthe basicinformationfor“SAFE
DRIVE”. Therefore, get a thorough knowl-
edge of the vehicle, in such a way as to be
able to drive in the traffic safely.
WARNING
CAUTION
WARNINGS - PRECAUTIONS -
GENERAL ADVICE

3
use and maintenance Atlantic 500
NOTEThis manual must be considered as
an integral part of the vehicle and must al-
ways accompany it,even in case of resale.
aprilia has carried out this manual with the
maximum attention,in order to supply the
user with correct and updated information.
However,since aprilia constantly improves
thedesignofits products, theremaybeslight
discrepanciesbetweenthecharacteristicsof
your vehicle and those described in this
manual.
For any clarification concerning the infor-
mationcontainedinthismanual,donot hesi-
tate to contact your aprilia Official Dealer.
For control and repair operations not ex-
pressly described in this publication, for the
purchaseofaprilia genuine spare parts,ac-
cessories and other products, as well as for
specific advice, contact exclusively aprilia
Official Dealers and Service Centers, which
guarantee prompt and accurate assistance.
Thank you for choosing aprilia. We wish
you a nice ride.
All rights as to electronic storage, repro-
duction and total or partial adaptation, with
any means, are reserved for all Countries.
NOTE In some countries the antipollution
and noise regulations in force require peri-
odical inspections.
The user of the vehicle in these countries
must:
– contactanaprilia OfficialDealer to have
the non-homologated components re-
placed with others homologated for use
in the country in question;
– carry out the required periodical inspec-
tions.
NOTE Soon after purchasing the vehicle,
write down the identification data indicated
on the SPARE PARTS IDENTIFICATION
LABEL in the table here below. The label is
stucktothelefttubeoftheframeandtoread
it it is necessary to remove the left inspec-
tion cover, see p.52 (REMOVING THE
RIGHTANDLEFTINSPECTIONCOVERS).
These data indicate:
– YEAR =year of manufacture (Y,1,2,...);
– I.M.=modification code (A,B,C,...);
– COUNTRY CODES =homologation coun-
try (I,UK,A,...).
andare to be supplied to the aprilia Official
Dealer as reference data for the purchase of
spare parts or specific accessories of the
model you have acquired.
In this manual the various versions are in-
dicated by the following symbols:
automatic light switching version
(Automatic Switch-on Device)
optional
VERSION:
Italy
United Kingdom
Austria
Portugal
Finland
Belgium
German
France
Spain
Greece
Holland
Switzerland
Denmark
Japan
Singapore
Israel
South Korea
Malaysia
Chile
United States
of America
Australia
Brazil
New Zealand
Canada
Croatia
Slovenia
South Africa

4
use and maintenance Atlantic 500
TABLE OF CONTENTS
SAFE GUIDE ...................................................... 5
BASIC SAFETY RULES .................................. 6
CLOTHING ..................................................... 9
ACCESSORIES............................................. 10
LOAD ............................................................. 10
ARRANGEMENT OF THE MAIN ELEMENTS .... 12
ARRANGEMENT OF THE CONTROLS /
INSTRUMENTS AND INDICATORS ................ 14
TABLE OF INSTRUMENTSAND INDICATORS .. 15
MAIN INDEPENDENT CONTROLS ................. 17
CONTROLS ON THE LEFT SIDE OF THE
HANDLEBAR................................................. 17
CONTROLS ON THE RIGHT SIDE OF THE
HANDLEBAR................................................. 18
IGNITION SWITCH ....................................... 19
STEERING LOCK ......................................... 19
DIGITAL CLOCK/DATE SETUP .................... 20
MULTIFUNCTION LCD DISPLAY ................. 21
DIGITAL ODOMETER ................................... 22
TOOL KIT ..................................................... 23
UNLOCKING/LOCKING THE SADDLE ........ 23
CRASH HELMET COMPARTMENT............. 24
GLOVE COMPARTMENT ............................. 24
MAIN COMPONENTS ...................................... 25
FUEL ............................................................. 25
LUBRICANTS ................................................ 26
BRAKE FLUID - RECOMMENDATIONS....... 27
DISK BRAKES............................................... 27
COOLANT ..................................................... 29
CHECKING AND TOPPING UP .................... 30
TYRES........................................................... 31
AUTOMATIC LIGHT SWITCHING VERSION ... 32
MUFFLER/EXHAUST SILENCER................. 32
INSTRUCTIONS FOR USE .............................. 33
TABLE OF PRELIMINARY CHECKS ............ 33
STARTING..................................................... 34
DEPARTURE AND DRIVE ............................ 36
BATTERY HYDROGEN GAS
AND ELECTROLYTE
STOPPING .................................................... 38
POSITIONING THE VEHICLE ON THE
STAND........................................................... 39
SUGGESTIONS TO AVOID THEFT .............. 40
MAINTENANCE ............................................... 40
REGULAR SERVICE INTERVALS CHART .. 41
IDENTIFICATION DATA ................................ 43
CHECKING THE ENGINE OIL LEVELAND
TOPPING UP ................................................ 44
REPLACING THE OILAND THE ENGINE
OIL FILTER .................................................... 45
CHECKING THE TRANSMISSION OIL
LEVELAND TOPPING UP ............................ 45
REPLACING THE TRANSMISSION OIL ...... 46
AIR CLEANER............................................... 47
CHECKING THE WEAR OF THE BRAKE
PADS ............................................................. 48
REAR BRAKE CALLIPER ............................. 49
CHECKING THE STAND .............................. 50
CHECKING THE SWITCHES ....................... 50
INSPECTING THE FRONTAND REAR
SUSPENSIONS............................................. 50
ADJUSTING THE REAR SUSPENSION ...... 51
CHECKING THE STEERING ........................ 51
CHECKING THE ENGINE FULCRUMAXIS.. 52
REMOVING THE RIGHTAND LEFT
INSPECTION COVERS ................................ 53
REMOVING THE FAIRING ........................... 53
REMOVING THE REAR-VIEW MIRRORS ... 54
REMOVING THE FRONT COVER ................ 54
ADJUSTING THE ACCELERATOR
CONTROL ..................................................... 55
SPARK PLUG ................................................ 56
BATTERY ...................................................... 57
LONG INACTIVITY OF THE BATTERY ........ 57
REMOVING THE BATTERY COVER ............ 58
CHECKING AND CLEANING THE
TERMINALS .................................................. 58
REMOVING THE BATTERY.......................... 58
CHECKING THE BATTERY
ELECTROLYTE LEVEL................................. 59
RECHARGING THE BATTERY ..................... 59
INSTALLING THE BATTERY ........................ 59
REPLACING THE FUSES ............................. 60
ARRANGEMENT OF THE SECONDARY
FUSES (FRONT COVER) ............................. 60
ARRANGEMENT OF THE PRIMARY
FUSES (BATTERY COMPARTMENT) .......... 61
VERTICALADJUSTMENT OF THE
HEADLIGHT BEAM ....................................... 61
HORIZONTALADJUSTMENT OF THE
HEADLIGHT BEAM ....................................... 62
BULBS ........................................................... 62
REPLACING THE BULBS OF THE FRONT
DIRECTION INDICATORS ............................ 62
REPLACING THE HEADLIGHT BULBS ....... 63
LOW BEAM BULBS ...................................... 63
HIGH BEAM BULBS...................................... 64
PARKING LIGHT BULBS .............................. 64
REPLACING THE REAR LIGHT BULB......... 64
REPLACING THE NUMBER PLATE BULB .. 65
REPLACING THE CRASH HELMET
COMPARTMENT BULB ................................ 66
REPLACING THE THIRD STOPLIGHT BULB .. 66
TRANSPORT ................................................... 67
DRAINING THE FUEL TANK ........................ 67
CLEANING ....................................................... 68
LONG PERIODS OF INACTIVITY ................ 69
TECHNICAL DATA ........................................... 70
LUBRICANT CHART ..................................... 74
WIRING DIAGRAM ....................................... 78