Bradley S19-110BF User manual

Installation
S19-110BF
Freestanding Drench Shower
Table of Contents
Pre-Installation Information ..............2
Installation Instructions.................. 3
Assembly of Components ...............4
Parts List ............................5
Bradley S19-110BF Free Standing Drench Shower Barrier Free
Bradley S19-110BFSS Stainless Steel Free Standing Drench Shower - Barrier Free
netzerotools.com
netzerotools.com
netzerotools.com

2
S19-110BF Installation
5/29/2012
IMPORTANT
Read this installation manual completely to ensure proper installation, then file it
with the owner or maintenance department. Compliance and conformity to drain
requirements and other local codes and ordinances is the responsibility of the installer.
Separate parts from packaging and make sure all parts are accounted for before
discarding any packaging material. If any parts are missing, do not begin installation
until you obtain the missing parts.
Flush the water supply lines before beginning installation and after installation is
complete. Test the unit for leaks and adequate water flow. Main water supply to the
eyewash should be “ON” at all times. Provisions shall be made to prevent unauthorized
shutoff.
The ANSI Z358.1 standard requires an uninterruptible supply of flushing fluid at a
minimum 30 PSI (0.21 MPa) flowing pressure. Flushing fluid should be tepid per ANSI
Z358.1.
The inspection and testing results of this equipment should be recorded weekly to verify
proper operation. This equipment should be inspected annually to ensure compliance
with ANSI Z358.1.
Workers who may come in contact with potentially hazardous materials should be
trained regarding the placement and proper operation of emergency equipment per ANSI
Z358.1.
Installation
THIS
SIDE
UP
Packing List
••••
P.O.Box309, Menomonee Falls, WI 53051
R
TESTTHISUNIT EACHWEEK
Test-operatevalve(s) each week and sign below.
Reportanymalfunctions immediately.
Ventil(e)wöchentlich im Testbetrieb prüfen, bestätigt
durchUnterschrift. Jegliche Störung sofort melden.
Date
Datum
Date
Signed
Unterschrift
Signe
Date
Date
Date Signed
Signed
Signed
DIESESGERÄT1ST WÖCHENTLICH ZU PRÜFEN.
ESSAIHEBDOMADAIRE
Testle fonctionnement des valves chaque semaine et
signeen bas. S'il y à quelquechose qui ne va pas fait
unrapport immédiatement.
P.O.BOX 309, MENOMONEE FALLS, WI 53052-0309 USA
TEL:1-800-BRADLEY FAX: [phone])
http://www.bradleycorp.com
114-051
netzerotools.com
netzerotools.com

3
Installation S19-110BF
5/29/2012
Installation
Supplies Required:
•฀(3)฀3/8"฀floor฀anchors฀and฀bolts•฀Teflon฀tape฀and฀pipe฀sealant•฀Piping฀to฀1-1/4"฀NPT฀water฀supply฀inlet฀on฀unit•฀฀Adequate฀supply฀pipe฀supports•฀Min.฀4"฀drain฀to฀accommodate฀30฀gallons฀per฀minute฀discharge฀for฀shower฀waste•฀OPTIONAL:฀sign-mounting฀hardwareStep 1: Secure base to floor
1.฀Install฀three฀suitable฀anchors฀(supplied฀by฀installer)฀for฀3/8"฀bolts฀in฀the฀floor.2.฀Bolt฀the฀base฀to฀the฀floor฀anchors฀using฀3/8"฀bolts฀(supplied by installer).
Step 2: Assemble components
1.฀Assemble฀the฀remaining฀unit฀components฀as฀shown฀on฀page฀4.•฀฀Apply฀pipe฀sealant฀(by฀installer)฀to฀all฀male-threaded฀pipe฀joints.•฀฀Use฀the฀rubber฀grip฀pad฀provided฀or฀a฀strap฀wrench฀around฀pipes฀when฀tightening฀to฀prevent฀marring.฀Place฀the฀grip฀pad฀on฀the฀pipe,฀then฀put฀the฀wrench฀over฀the฀grip฀pad฀and฀turn฀the฀pipe฀with฀the฀wrench.•฀฀Bottom฀edge฀of฀showerhead฀should฀be฀7'-0"฀(2134mm) from floor.
Step 3: Connect water supply
IMPORTANT: Do not rely on Bradley’s
Combination Unit to support supply piping.
1.฀Connect฀water฀supply฀piping฀to฀1-1/4"฀NPT฀inlet฀on฀unit฀(piping฀by฀installer).฀Provide฀adequate฀supports฀(by฀installer)฀for฀supply฀pipe฀using฀pipe฀hangers฀or฀other฀means.2.฀Hang฀the฀safety฀sign฀from฀the฀unit฀with฀the฀curtain฀hooks฀provided฀(or฀mount฀it฀to฀the฀wall฀using฀sign-mounting฀hardware฀by฀installer).NOTE: All dimensions assume standard thread
engagement. Variations in manufacturing allow for
+/- 1/8" (3mm) per threaded joint. To find the tolerance
of a dimension, add the number of thread joints in
between a dimension and multiply it by 1/8" (3mm).
33-3/8"
(847mm)
4-1/2"
(114mm)
3.1"
(78.7mm) 45"
(1142mm)
9"
(229mm)
42"
(1067mm)
to Floor
7'1"
(2159mm)
to Floor
Ø 9" (229mm) Flange
with (3) Ø 3/8" (10mm)
Holes on Ø 8" (203mm)
Bolt Circle
netzerotools.com
netzerotools.com

4
S19-110BF Installation
5/29/2012
Assembly of Components
P.O. Box 309, Menomonee Falls,WI 53051
R
TESTTHIS UNIT EACH WEEK
Test-operatevalve(s) each week and sign below.
Report any malfunctions immediately.
Ventil(e)wöchentlich im Testbetrieb prüfen, bestätigt
durch Unterschrift. Jegliche Störung sofort melden.
Date
Datum
Date
Signed
Unterschrift
Signe
Date
Date
Date Signed
Signed
Signed
DIESES GERÄT 1STWÖCHENTLICH ZU PRÜFEN.
ESSAI HEBDOMADAIRE
Testle fonctionnement des valves chaque semaine et
signe en bas.S'il y à quelque chose qui ne va pas fait
un rapport immédiatement.
P.O. BOX 309, MENOMONEE FALLS,WI 53052-0309 USA
TEL: 1-800-BRADLEY FAX: [phone])
http://www.bradleycorp.com
114-050
15
16
17
1
2
2
3
5
6
6
7
8
9
12
13
11
14
10.210.310.4
10.5
10.11
10.1
10
4
2
ALIGN
HANDLE
PIECES
AS SHOWN 1-1/4"฀NPT฀Supply Inlet 1-1/4"฀NPT฀Supply Inlet
NOTE:฀฀If฀tee฀(Item฀7)฀is฀used฀as฀the฀supply฀inlet,฀then฀relocate฀pipe฀plug฀(Item 4) and one
coupling฀(Item฀2)฀to฀this฀location.NOTE:฀Items฀10.1–10.5฀come฀preassembled฀as฀Item฀10.NOTE: Use
teflon tape
only.
netzerotools.com
netzerotools.com

5
Installation S19-110BF
5/29/2012
Parts List
Item Part No. Qty. Description
1131-059 1 Base
2 169-853 3 Coupling฀1-1/4"3 113-1181 1 Pipe฀1-1/4"฀NPT฀x฀31"4 S06-136 1 Pipe฀Plug5 169-727 1 Pipe฀Tee฀1-1/4"฀NPT6 113-006LW 2 Pipe฀1-1/4"฀NPT฀x฀22-1/2"7 169-722 1 Red.฀Tee฀1-1/4"฀x฀1-1/4"฀x฀1"฀NPT8 169-724 1 Sq.฀Head฀Pipe฀Plug฀1-1/4"฀NPT9 269-434 1 Pipe฀1"฀NPT฀x฀9"10 S30-059 1 Stay-Open฀Ball฀Valve฀1"฀NPT10.1 S27-278 1 Ball฀Valve฀1"฀with฀Jam฀Nut10.11 110-214 1 Jam฀Nut฀onlyItem Part No. Qty. Description
10.2 140-720 1 Stop฀Bracket10.3 124-048 1 Friction฀Washer10.4 128-129 1 Handle
10.5 142-002DC 1 Lockwasher11 151-001 2 Curtain฀Hook12 S90-365D 1 Pull Rod
13 113-006LK 1 Pipe฀1"฀NPT฀x฀12"14 169-847 1 90°฀Elbow฀1"฀NPT15 S24-188 1 Plastic฀Showerhead฀Assembly16 114-050 1 Safety฀Sign17 204-421 1 Emergency฀Inspection฀Tag18 269-915 1 Grip฀Pad฀(not฀shown)
netzerotools.com
netzerotools.com