Cognex DataMan 370 Series User manual

DataMan®370 Series
Quick Reference Guide
2020 October 05
Revision: 6.2.1.1

Precautions
To reduce the risk of injury or equipment damage, observe the following precautions
when you install the Cognex product:
lThe reader is intended to be supplied by a UL or NRTL listed power supply
with a 24VDC output rated for at least 2A continuous and a maximum short
circuit current rating of less than 8A and a maximum power rating of less
than 100VA and marked Class 2 or Limited Power Source (LPS). Any other
voltage creates a risk of fire or shockand can damage the components.
Applicable national and local wiring standards and rules must be followed.
lRoute cables and wires away from high-current wiring or high-voltage
power sources to reduce the risk of damage or malfunction from the
following causes: over-voltage, line noise, electrostatic discharge (ESD),
power surges, or other irregularities in the power supply.
lDo not install Cognex products where they are exposed to environmental
hazards such as excessive heat, dust, moisture, humidity, impact, vibration,
corrosive substances, flammable substances, or static electricity.
lDo not expose the image sensor to laser light. Image sensors can be
damaged by direct, or reflected, laser light. If your application requires laser
light that might strike the image sensor, use a lens filter at the corresponding
laser wavelength. For suggestions, contact your local integrator or
application engineer.
lChanges or modifications not expressly approved by the party responsible
for regulatory compliance could void the user’s authority to operate the
equipment.
lInclude service loops with cable connections.
2

lEnsure that the cable bend radius begins at least six inches from the
connector. Cable shielding can be degraded or cables can be damaged or
wear out faster if a service loop or bend radius is tighter than 10X the cable
diameter.
lThisdevice should be used in accordance with the instructions in this
manual.
lAll specifications are for reference purposes only and can change without
notice.
Product Overview
1Lens
2Illumination LED clusters
3 Mounting holes (M3 x 5mm)
4 Indicator light ring
5 Trigger button
6 Power
7 Train status
8 Read/no-read indicator
3

9 Network
10 Error
11 Peak meter
12 Tuning button
13 Ethernet
14 SD card slot
15 External light control
16 Power, I/O, and RS-232
DataMan 370 Series Accessories
LENS OPTIONS AND COVERS
Accessory DM374 DM375
8 mm F5.6 fixed aperture lens LEC-CFF08-
F5.6
12 mm F8 fixed aperture lens LEC-CFF12-
F8
16 mm F8 fixed aperture lens LEC-CFF16-
F8
25 mm F8 fixed aperture lens LEC-CFF25-
F8
35 mm F8 fixed aperture lens LEC-CFF35-
F8
40 mm F8 fixed aperture lens LEC-CFF40-
F8
50 mm F8 fixed aperture lens LEC-CFF50-
F8
4

Accessory DM374 DM375
Liquid lens module and pre-focused 10.3* mm or
10.3 mm IR** M12 lens with wrench
DMLN-10LL-
SMT
DMLN-10LL-
IR-SMT
24 mm F6 liquid lens module* DM360-
LENS-24LL
24 mm F6 liquid lens module*** DMLN-
C24F06-LL-
IR
24 mm F10 liquid lens module* DMLN-
C24F10-LL
10 mm F5 autofocus lens* (use with HPIT) DMLN-
C10F05-
HSLL
16 mm F8 autofocus lens* (use with HPIT) DMLN-
C16F08-
HSLL
24 mm F6 autofocus lens* (use with HPIT) DMLN-
C24F06-
HSLL
35 mm F8 autofocus lens* (use with HPIT) DMLN-
C35F08-
HSLL
* With built-in IR blocking filter
** Without built-in IR blocking filter
*** Without built-in IR blocking filter, and with built-in daylight filter
LENSCOVERSANDINTEGRATEDILLUMINATIONS
5

Accessory DM374 DM375
C-Mount cover for C-Mount lenses DM300-
CMCOV
Short C-Mount cover for C-Mount lenses DM300-
CMCOV-
SH
Extension kit DM300-
EXT
DM500 C-Mount cover (use with HPIA) DM500-
CMTLC-
000
DM500 Lens cover extender DM500-
LNSEXT-
000
6

Accessory DM374 DM375
Red LED HPIL, 10.3 mm lens
(RiskGroup Red LED Exempt acc. IEC 62471, RiskGroup
Green LED AimerExempt acc. IEC 62471)
DM360-
HPIL-RE
Polarized red LED HPIL, ESD safe, 10.3 mm lens
(RiskGroup Red LED Exempt acc. IEC 62471, RiskGroup
Green LED AimerExempt acc. IEC 62471)
DM360-
HPIL-RE-P
White LED HPIL, 10.3 mm lens
(RiskGroup White LED low riskacc. IEC 62471, RiskGroup
Green LED AimerExempt acc. IEC 62471)
DM360-
HPIL-WHI
Red LED HPIL, 24 mm liquid lens
(RiskGroup Red LED Exempt acc. IEC 62471, RiskGroup
Green LED AimerExempt acc. IEC 62471)
DMLT-
HPIL-RE
Polarized red LED HPIL, ESD safe, 24 mm liquid
lens
(RiskGroup White LED low riskacc. IEC 62471, RiskGroup
Green LED AimerExempt acc. IEC 62471)
DMLT-
HPIL-RE-P
White LED HPIL, 24 mm liquid lens
(RiskGroup White LED low riskacc. IEC 62471, RiskGroup
Green LED AimerExempt acc. IEC 62471)
DMLT-
HPIL-WHI
Infrared LED HPIL, ESD safe, 10.3 & 24 mm liquid
lens
(RiskGroup IR LED Exempt acc. IEC 62471, RiskGroup
Green LED AimerExempt acc. IEC 62471)
DMLT-
HPIL-IR-W
EXTERNAL LIGHTS ANDHIGHPOWERILLUMINATIONS
Accessory DM374 DM375
Ring Light CLRR-R7030G1CLR
Back light CLRB-F100100G1
7

Accessory DM374 DM375
Coaxial (DOAL) light CLRO-K5050G1
Spot light CLRS-P14G1
Dark-field light CLRD-D120G1
Brick light, narrow blue IVSL-ODDM-S75-470
Brick light, narrow red IVSL-ODDM-S75-625
Brick light, narrow white IVSL-ODDM-S75-WHI
Bar light, wide red IVSL-YLW2X-625
Bar light, narrow red, linear polarizer IVSL-YLW2X-625P
Bar light, narrow infrared IVSL-YLW2X-850
Bar light, narrow blue IVSL-YLW2X-470
Bar light, wide red IVSL-YLW2X-625-W
Bar light, narrow white IVSL-YLW2X-WHI
Bar light, wide white IVSL-YLW2X-WHI-W
Bar light, wide white, linear polarizer IVSL-YLW2X-WHIP-W
Bar light, blue IVSL-LX520-470
Bar light, red IVSL-LX520-625
8

Accessory DM374 DM375
LX280-series light, blue IVSL-LX280-470
LX280-series light, red IVSL-LX280-625
Bar light, red IVSL-LX800-625
Linear Polarizer Kit Case DM30X-HPIA3-LP
HPIA, Red narrow DM30X-HPIA3-625
HPIA, Red wide DM30X-HPIA3-625-W
HPIA, White narrow
(RiskGroup White LED low riskacc. IEC 62471)
DM30X-HPIA3-WHI
HPIA,White wide
(RiskGroup White LED low riskacc. IEC 62471)
DM30X-HPIA3-WHI-W
HPIA, Blue narrow
(RiskGroup White LED low riskacc. IEC 62471)
DM30X-HPIA3-470
HPIA, Blue wide
(RiskGroup White LED low riskacc. IEC 62471)
DM30X-HPIA3-470-W
HPIA, Infrared narrow
(RiskGroup White LED low riskacc. IEC 62471)
DM30X-HPIA3-IR
HPIA, Infrared wide
(RiskGroup White LED low riskacc. IEC 62471)
DM30X-HPIA3-IR-W
9

Accessory DM374 DM375
HPIT, Red, wide, 10 and 16 mm lens
(RiskGroup Red LED exempt riskacc. IEC 62471)
DMLT-HPIT-RE-W
HPIT, Red, standard, 24 mm lens
(RiskGroup Red LED exempt riskacc. IEC 62471)
DMLT-HPIT-RE-S
HPIT, White, wide, 10 and 16 mm lens
(RiskGroup White LED low riskacc. IEC 62471)
DMLT-HPIT-WHI-W
HPIT, White, standard, 24 mm lens
(RiskGroup White LED low riskacc. IEC 62471)
DMLT-HPIT-WHI-S
HPIT, Red, narrow
(RiskGroup Red LED exempt riskacc. IEC 62471)
DMLT-HPIT-RE-N
HPIT, White, narrow
(RiskGroup White LED low riskacc. IEC 62471)
DMLT-HPIT-WHI-N
Polarized front cover DMLA-HPIT-PLCOV
Clear front cover DMLA-HPIT-CLCOV
Diffuse front cover DMLA-HPIT-DLCOV
Passive Dome front cover DMLA-HPIT-DFCOV
Adapter (includes PCB light port adapter) DMLA-HPIT-ADAP370
FIELDOFVIEWEXPANDERS
10