rollease acmeda Easy Link User manual





EASY‐LINK
ASSEMBLYMANUAL

February2016


 


CONTENTS
February2016
ThismanualistobereadinconjunctionwiththeProductSpecificationsmanual

SECTIONNO.DESCRIPTIONPAGENO.

SECTION1−TOOLSANDADDITIONALITEMSREQUIRED1.1
SECTION2−SYSTEMDETAILS2.1
PARTB–DEDUCTIONS2.2
PARTC–BOM&CUTTINGLIST2.2
SECTION3‐ASSEMBLY3.3
PARTA–ASSEMBLINGTUBE3.3
PARTB–PREPARE&PACKASSEMBLIESREADYFORTRANSPORTATION&INSTALLATION3.5


DISCLAIMER
INTRODUCTION
ThisassemblymanualhasbeenproducedbyRolleaseAcmedatosupplythenecessaryinformationforsafeandcorrectassemblyofthissystem.
DISCLAIMER
RolleaseAcmedahasusedreasonablecareinpreparingtheinformationincludedinthisdocument,butmakesnorepresentationsorwarrantiesastothecompletenessor
accuracyoftheinformation.Informationissuppliedupontheconditionthatthepersonsreceivingtheinformationwillmaketheirowndeterminationastoitssuitability
fortheirpurposespriortouse.RolleaseAcmedaassumesnoliabilitywhatsoeverforanydamagesincurredbyyouresultingfromerrorsinoromissionsfromthe
informationincludedherein.RolleaseAcmedareservestherighttomakechangeswithoutfurthernoticetoanyproductstoimprovereliability,functionordesign.
COPYRIGHT
COPYRIGHT©ROLLEASEACMEDA2016
Allrightsreserved.Nopartofthisdocumentmaybereproducedorutilisedinanymeans,byanymeans,electronicormechanicalincludingphotocopying,recordings,or
byanyinformationstorageorretrievalsystem,withouttheexpresspermissionfromRolleaseAcmeda.







Page1.1EASY‐LINKAssemblyManual|February2016
Copyright©2016RolleaseAcmedaGroup.


SECTION1−TOOLSANDADDITIONALITEMSREQUIRED

TOOLSREQUIRED
Saw
Drill
DrillBits
ScrewDriver–PhilipsHead,FlatHead
Scissors
MeasuringTape
Pencil

ADDITIONALITEMSREQUIRED(NOTSUPPLIED)
ToassembleanEASY‐LINK,thefollowingnon‐stockeditemsarerequired:
Fabric







Page2.1EASY‐LINKAssemblyManual|February2016
Copyright©2016RolleaseAcmedaGroup.


SECTION2−SYSTEMDETAILS

PARTA–GENERALSCHEMATICS
TheRolleaseAcmedaEasy‐Link™systemwasdesignedtoallowformultipleblindstobecontrolledusingasinglemotororchaincontrol
operation.Achievingminimalgapsbetweeneachblind,theEasy‐Link™systemprovidestheperfectadditiontotheEasy‐Lockrangewhenlinking
blinds.

SYSTEMINDEX
ROLLERADONSYSTEM–EASY‐LINK

1. Easy‐LinkLXIntermediateBearingBracket
2. Easy‐LinkIntermediateMALEDrive
3. Easy‐LinkIntermediateFEMALEDrive&IdleAdaptor

 

1
23


Page2.2EASY‐LINKAssemblyManual|February2016
Copyright©2016RolleaseAcmedaGroup.





PARTB–DEDUCTIONS
PARTC–BOM&CUTTINGLIST
EASY‐LINK

  PARTNUMBERDESCRIPTIONU.O.MQTYDEDUCTION
      
EASY‐LINK
OPTIONS

BRACKETS 
RB41‐0353‐XXX040  Easy‐LinkLxInter.BearingBkt‐40mmS45  Piece 
n

RB41‐0353‐XXX055Easy‐LinkLXInter.BearingBkt‐55mmS45Piece 
DRIVES
RB41‐1002‐XXX045Easy‐LinkIntermediateMALEDriveS45Set1x
n 
RB41‐1001‐XXX045Easy‐LinkIntermediateFEMDrive&IdleAdaptor
S45
Set1x
n 

Note: n =numberofEasy‐LinkBracketsrequiredforinstallation
EASY‐LINK



FABRIC/TUBELIGHTGAP
EASY‐LINK19mm
(0.75”)




Page3.3EASY‐LINKAssemblyManual|February2016
Copyright©2016RolleaseAcmedaGroup.




SECTION3‐ASSEMBLY


STEP2–INSERTINTERMEDIATEFEMALEEASY‐LINKINTOBLIND“B”




PARTA–ASSEMBLINGTUBE
STEP1–INSERTINTERMEDIATEMALEEASY‐LINKDRIVEINTOBLIND“A”


Page3.4EASY‐LINKAssemblyManual|February2016
Copyright©2016RolleaseAcmedaGroup.





STEP3–INSERTINTERMEDIATEMALEANDFEMALEEASY‐LINKDRIVEINTOBLIND“X”(WHENUSING3+BLINDS)




NOTE:Repeatstep3foreachBlind“X”beingused


Page3.5EASY‐LINKAssemblyManual|February2016
Copyright©2016RolleaseAcmedaGroup.






PARTB–PREPARE&PACKASSEMBLIESREADYFORTRANSPORTATION&INSTALLATION
EASY‐LINK


5
4
2
3
1
1
2
Checkyouhaveallblinditems;

1.Easy‐LockLXBracket
2.Easy‐LinkLXBearingBracket
3.Blind“A”(IdlerSide)
4.Blind“B”(ControlSide)
5.Blind“X”(LinkingBlind)
( OPTIONAL:THERECANALSOBE
MULTIPLE OF BLIND
“
X
”
)