Saxby Lighting 13929 User manual

Pyramid LED Post Light
13929

• Thisfittingmustbemountedoneitheraconcretesurfaceorapavingslabthathasbeenconcretedinposition
• Planthedesiredlayoutofthisfittingcarefully,ensuringthecableswillreachthedistancebetweenthejunction
boxandthelightfitting.
• Avoidlocatinganycablesinpositionsthatwouldcauseahazard.Positioncablesandoutdoorratedjunction
boxes(notsupplied)awayfromareaswheretheymaybeatriskfrombeingcut,trappedordamaged.
• WerecommendthatyouuseH05RN-Fspecificationcable(notsupplied)whichisanoutdoorgrade,rubber
sheathedcable.Themainssupplycablemusthaveaminimumcrosssectionalareaof1.0mm²
• Cablesmustbeprotectedusingsuitableconduitorplastictrunking.
Thankyouforpurchasingthislightfitting.
Pleasereadtheinstructionscarefullybeforeusetoensuresafeandsatisfactoryoperationofthisproduct.
Pleaseretaintheseinstructionsforfuturereference.
Warning
Specification
Layout
This is a Class 1 product and must be earthed.
Pleasereadtheseinstructionscarefullybeforecommencinganywork.
Thisunitmustbefittedbyacompetentandqualifiedelectrician.
InstallinaccordancewithIEEWiringregulationsandcurrentBuildingRegulations.
Topreventelectrocutionswitchoffatmainssupplybeforeinstallingormaintainingthisfitting.Ensureotherpersons
cannotrestoretheelectricalsupplywithoutyourknowledge.Ifyouareinanydoubt,pleaseconsultaqualified
electrician.
Thislightfittingshouldbeconnectedtoacircuitwitha30mARCDfitted.
Ifreplacinganexistingfitting,makeacarefulnoteoftheconnections.
Thissystemcontainsnon-replaceablepartsandcannotbeserviced.Ifdamageoccursthepartshouldbescrapped.
Wasteelectricalproductsshouldnotbedisposedofwithhouseholdwaste.Pleaserecyclewherefacilitiesexist.
Checkwithyourlocalauthorityorretailerforrecyclingadvice.
Thisproductisnotsuitablefordimming.
ThisproductisratedatIP44.
Thisproductisnotsuitableforlocationinornearamarineorseaenvironment.
Theentireunitgetshotwhilstonforaperiodoftime.
Voltage: 240V50Hza.c.
Lamp: 4.5WMax.36LED’s
IPrating: 44
76.0mm dia
500.0mm
117.0mm dia

Youhavecorrectlyidentifiedthewires.
Theconnectionsaretight.
Noloosestrandshavebeenleftoutoftheconnectionblock.
Installation
Wiring
Check That
Existingfittingsmustbecompletelyremoved
before installation of a new product. Before
removingthe existingfitting, carefully note
the position of each set of wires.
1. Usingbaseplateasatemplate,markthe
fixingholesontothemountingsurface.
2. Drill holes to the necessary size and
depth - taking care not to damage any
concealed pipes or wiring below the
mountingsurface.
3. Werecommendfittingthisproductwith
screws (A) which are suitable for use
on most surfaces, however alternative
fixingsmayberequired.
4. Pushtherawplugs(B)intothemounting
holesasshown.
5. Wireasdetailedbelow.
A
C
B
Havingcorrectlyidentifiedthewiringfromyour
existinglightfitting,pullthewirethroughthehole
andconnecttotheconnectionblockinsidethe
productinthefollowingway:
5. Pullterminalblock(D)frominsideoftube.
6. Unscrewthe4screwswhichattachtheblack
boxtothespacingstrip.Opentheblackbox
andpullouttheterminalblock.
7. ConnectLiveinputwiretobrownwire
onproduct(orterminalonterminalblock
marked‘L’).
8. ConnectNeutralinputwiretobluewire
onproduct(orterminalonterminalblock
marked‘N’).
9. ConnectInputEarthwire(Green/yellow)to
Earthwireonfitting,
10. Checkthatyouhavecorrectlyidentifiedthe
supplywires,theconnectionsaretightand
thatnoloosestrandshavebeenleftoutofthe
connectionblock.
11. Pushterminalblockbackintotheblackbox,
andrefittheterminalblcokcover.
Cable wired to product
Terminal block case
Supply cable
Spacing strip
LIVE
wires
NEUTRAL
wires
EARTH
wire
EARTH
wire

Wasteelectricalproductsshouldnotbedisposedofwithhouseholdwaste.Pleaserecyclewhere
facilitiesexist.CheckwithyourLocalAuthorityorretailerforrecyclingadvice.
SaxbyLightingLtd.BH233PE
Care and Cleaning
Recycling Advice
Safety Information
Wasteelectricalproductsshouldnotbedisposedofwithhouseholdwaste.Pleaserecyclewherefacilitiesexist.
The shade must be replaced immediately should the shade become cracked or damaged. This
tting must not be used without the shade in place.
Replace Cracked
Shade
Foryoursafety,alwaysswitchoffthesupplybeforechanginglightbulbs,cleaningorremovingshades.
Fitting / Replacing Bulbs
12. Pushtheterminalblockupintothetube.
13. Locatetheproductinpositionandfitthescrewstosecureinplace.
14. Replacefuseorcircuitbreakerandswitchon.Yourlightisnowreadyforuse.
Commissioning
Donotusesolventsorabrasivecleanersasthesecoulddamagethefinish.
Innormalcircumstances,stainlesssteelisveryresistanttocorrosion.Itdoeshoweverrequiremaintenanceto
preservethehighqualityappearance.Washtheproductwithwarmsoapywater,removingallsurfacedeposits.Rinse
withclearwaterandwithasoftcloth,wipedry.
Insomecases,surfacecorrosionmayariseafterinstallation.Thisisnormallycausedbytinyironparticlesleftbehind
afterthebrushingprocesswhenfinishing.
Washanddryasdetailedabove.Thenwithasoftclothsoakedwithaprotectiveoil,wipeallover.
Howeveriftheproductissubjecttoextremeenvironmentalconditionssuchasmarinelocations,industrial
pollutionandacidrainthesemaintenanceproceduresshouldbecarriedoutaroundfourtimesayear.Forsevere
corrosion,non-abrasivecreamcleanersorproprietarystainlesssteelcleanersshouldbeusedtoremovethe
corrosion.Washanddryasdetailedabove.Thenwithasoftclothsoakedwithaprotectiveoil,wipeallover.
Do not clean the units with a pressure washer.
Iss.107122010